Product ID:BLAZO FUEL
MSDS Date:09/22/1989
FSC:9150
NIIN:00F004836
MSDS Number: BVRHJ

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

15299 SAN PABLO AVE
RICHMOND, CA 94804
US

Emergency Phone: 800-457-2022/510-233-3737

Info Phone: 415-233-3737

Cage: 0AHD1

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

4054 RICHMOND, CA 94804 US

Telephone: 800-582-3835

Cage: 0AHD1

BENZENE (SUSPECTED HUMAN CARC BY ACGIH, IARC, SUSPECTED

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: <0.2%

OSHA PEL 1 PPM

ACGIH TLV: 0.3 MG/CUM (A2) IC

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

NAPHTHA (PETROLEUM), SWEETENED

CAS: 64741-87-3

RTECS: QK8030000

Fraction By Weight: <84%

HEXANE, N-HEXANE

CAS: 110-54-3

RTECS: MN9275000

Fraction By Weight: <10%

OSHA PEL 1800 MG/CUM

ACGIH TLV: 176 MG/CUM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

CYCLOHEXANE

CAS: 110-82-7

RTECS: GU6300000

Fraction By Weight: <3%

OSHA PEL 1050 MG/CUM

ACGIH TLV: 1030 MG/CUM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TOLUENE (IARC - GROUP 3) *94-3*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <2%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

XYLENE, DIMETHYLBENZENE, XYLOL

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: <1%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ETHYL BENZENE

CAS: 100-41-4

RTECS: DA0700000

Fraction By Weight: <0.3%

OSHA PEL 435 MG/CUM

ACGIH TLV: 434 MG/CUM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CYCLOPENTANE

CAS: 287-92-3

RTECS: GY2390000

Fraction By Weight: 1%

OSHA PEL 600 PPM

ACGIH TLV: 1,720 MG/CUM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: SLIGHT IRRITATION. SKIN:
ABSORPTION, MODERATE IRRITATION. INGESTION: SLIGHTLY TOXIC TO
INTERNAL ORGANS, ABSORPTION IN GUT, ASPIRATION INTO LUNGS CAUSING
SEVERE INJURY & DEATH. CHRONIC: PROLONGED BREATHING OF VAPORS CAN
CAUSE CNS EFFECTS. PROLONGED EXPOSURE CAN CAUSE VISION IMPAIRMENT &
SKIN INJURY.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, PAIN, TEARS, SWELLING, REDNESS,
BLURRED VISION, FEELING OF HEAT, DISCOLORATION, BLISTERING,
HEADACHE, DIZZINESS, LOSS OF APETITE, WEAKNESS, LOSS OF
COORDINATION

First Aid:EYES: FLUSH W/FRESH WATER FOR AT LEAST 15 MINS. REMOVE
CONTACT LENSES IF WORN. SKIN: WASH THOROUGHLY W/SOAP & WATER.
INHALATION: MOVE TO FRESH AIR. INGESTION: GIVE WATER/MILK TO DRINK.
DON'T MAKE PERS ON VOMIT UNLESS DIRECTED TO DO SO BY MEDICAL
PERSONNEL. ASPIRATION HAZARD. OBTAIN MEDICAL ATTENTION IN ALL
CASES.

Flash Point Method:TCC
Flash Point:-49F
Lower Limits:1.4
Upper Limits:7.6
Extinguishing Media:CO2, DRY CHEMICAL, FOAM, WATER FOG
Fire Fighting Procedures:DON'T ENTER ANY ENCLOSED/CONFINED SPACE W/OUT
PROPER PROTECTIVE EQUIPMENT INCLUDING SCBA.
Unusual Fire/Explosion Hazard:LIQUID QUICKLY EVAPORATES, EVEN AT LOW
TEMPS, & FORMS VAPOR WHICH CAN CATCH FIRE & BURN W/EXPLOSIVE
VIOLENCE. VAPOR SPREADS EASILY & IS IGNITED BY MANY SOURCES.

Spill Release Procedures:ELIMINATE ALL OPEN FLAME IN AREA. STOP LEAK
SOURCE. WEAR APPROPRIATE PROTECTIVE EQUIPMENT. CONTAIN LIQUID TO
PREVENT CONTAMINATION OF SOIL, SURFACE WATER/GROUNDWATER. CLEAN UP
W/ABSORBENT MATERIALS/BY PUMPING. REMOVE CONTAMINATED SOIL.

Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T
STORE/USE NEAR FLAME, SPARKS, HOT SURFACES. USE ONLY IN WELL
VENTILATED AREA. KEEP CONTAINER CLOSED.
Other Precautions:DON'T WELD, HEAT/DRILL CONTAINER. REPLACE CAP/BUNG.
EMPTIED CONTAINER STILL CONTAINS HAZARDOUS/EXPLOSIVE VAPOR/LIQUID.
DON'T USE PRESSURE TO EMPTY DRUM/EXPLOSION MAY RESULT. READ &
OBSERVE ALL PRECAUT IONS ON PRODUCT LABEL.

Respiratory Protection:OSHA APPROVED RESPIRATOR IF AIRBORNE
CONCENTRATIONS ARE BELOW RECOMMENDED EXPOSURE STANDARDS.
Ventilation:USE ONLY IN WELL-VENTILATED AREAS.
Protective Gloves:REQUIRED
Eye Protection:CHEMICAL GOGGLES & FACE SHIELD
Work Hygienic Practices:REMOVE & LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DISCARD CONTAMINATED NON-WATERPROOF SHOES & BOOTS.
Supplemental Safety and Health

Boiling Pt:B.P. Text:108-280.4F
Vapor Pres:3.8 PSIA
Vapor Density:3.7
Spec Gravity:0.71
Evaporation Rate & Reference:(BU AC=1): 1.26
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS LIQUID
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, CHLORATES, NITRATES, PEROXIDES
Stability Condition to Avoid:IGNITION SOURCES, FLAME, SPARKS, HOT
SURFACES
Hazardous Decomposition Products:CO2, WATER VAPOR, CO

Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS & DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.